[1]劉超,吳紅娟,羅玖淇,等.MBBR工藝用于北方某污水廠提標改造的效果[J].中國給水排水,2025,41(7):76-81.
LIUChao,WUHong-juan,LUOJiu-qi,et al.Impact of MBBR Process on Upgrade of a Wastewater Treatment Plant in Northern China[J].China Water & Wastewater,2025,41(7):76-81.
點擊復制
LIUChao,WUHong-juan,LUOJiu-qi,et al.Impact of MBBR Process on Upgrade of a Wastewater Treatment Plant in Northern China[J].China Water & Wastewater,2025,41(7):76-81.
MBBR工藝用于北方某污水廠提標改造的效果
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第41卷 期數: 2025年第7期 頁碼: 76-81 欄目: 出版日期: 2025-04-01
- Title:
- Impact of MBBR Process on Upgrade of a Wastewater Treatment Plant in Northern China
- 關鍵詞:
- 移動床生物膜反應器(MBBR); 原位提標改造; 硝化性能; 生物膜; 降耗
- Keywords:
- moving bed biofilm reactor (MBBR); in-situ upgrade and transformation; nitrification performance; biofilm; energy saving
摘要:- 北方某污水處理廠一期設計規模為50×104 m3/d，設計出水水質執行國家一級A標準，需要提標至《子牙河流域水污染物排放標準》（DB 13/2796—2018）中重點控制區排放限值標準。該污水廠采用移動床生物膜反應器（MBBR）工藝進行升級改造，改造后生化池出水COD、TP、NH4+-N、TN分別為（16.2±3.9）、（0.2±0.2）、（0.18±0.1）、（8.1±2.2） mg/L。改造后出水水質穩定優于設計排放標準，原水碳源利用率提高了63.14%，減少了36.5%的外碳源投加量和43.4%的聚合氯化鋁（PAC）投加量。系統中的優勢硝化菌屬為Nitrospira，其在生物膜中的相對豐度達到7.31%，是活性污泥中的6.5倍�；贛BBR的原位改造實現了系統脫氮與除磷能力的同步提升，保障了出水水質的穩定達標，同時降低了運行費用。
Abstract:- The design capacity of the phase Ⅰ project of a wastewater treatment plant in northern China is 50×104 m3/d. The effluent quality is designed to meet the first level A criteria specified in the national discharge standard, but it needs to be upgraded to comply with the discharge limit for key control areas as specified in Ziya River Basin Water Pollutants Discharge Standards (DB 13/2796-2018). The project employed the moving bed biofilm reactor (MBBR) process for its upgrade and transformation. After transformation, the chemical oxygen demand, total phosphorus, ammonia nitrogen and total nitrogen in the effluent from the biochemical tank were (16.2±3.9) mg/L, (0.2±0.2) mg/L, (0.18±0.1) mg/L and (8.1±2.2) mg/L, respectively. In addition, the effluent quality was stable and better than the design discharge standard. The utilization rate of the carbon source in the raw water increased by 63.14%, while the dosage of external carbon sources and polyaluminum chloride (PAC) was reduced by 36.5% and 43.4%, respectively. The predominant nitrifying bacteria in the system was Nitrospira, with a relative abundance of 7.31% in the biofilm, which was 6.5 times higher than that in the activated sludge. The MBBR-based in-situ transformation achieved concurrent enhancement of the system’s nitrogen and phosphorus removal capabilities, ensured stable and compliant effluent quality, and reduced operation costs.
相似文獻/References:
[1]顧瑞環,劉旭陽,畢學軍,等.曝氣量分配和填料填充率對MBBR氧轉移效率的影響[J].中國給水排水,2023,39(1):1.
GURui-huan,LIUXu-yang,BIXue-jun,et al.Effect of Aeration Distribution and Carrier Filling Rate on Oxygen Transfer Efficiency of MBBR[J].China Water & Wastewater,2023,39(7):1.
[2]梁一帆,潘增銳,喻盛華,等.MBBR污水生化處理系統中泥膜的生物群落分析[J].中國給水排水,2023,39(23):15.
LIANGYi-fan,PANZeng-rui,YUSheng-hua,et al.Microbial Community of Sludge and Biofilm in a Moving Bed Biofilm Reactor[J].China Water & Wastewater,2023,39(7):15.
更新日期/Last Update: 2025-04-01
