PDF下載
[1]趙林輝,林莉峰,朱運濤.大型污泥焚燒項目的污泥脫水運行優化研究[J].中國給水排水,2021,37(12):145-150.
ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao.Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project[J].China Water & Wastewater,2021,37(12):145-150.點擊復制
大型污泥焚燒項目的污泥脫水運行優化研究
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第37卷 期數: 2021年第12期 頁碼: 145-150 欄目: 出版日期: 2021-06-17
Title:Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project
作者:趙林輝，林莉峰，朱運濤(上海市政工程設計研究總院<集團>有限公司，上海200092)
Author(s):ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao(Shanghai Municipal Engineering Design Institute Co. Ltd., Shanghai 200092, China)
關鍵詞:污泥焚燒; 污泥脫水; 運行優化
Keywords:sludge incineration; sludge dewatering; operation optimization
摘要:介紹了白龍港污水處理廠污泥處理處置二期工程離心脫水系統的工藝設計、設備參數和進泥參數校正情況，并以實際調試為依據，對影響離心脫水機出泥含水率的幾個重要因子（藥劑投加量、污泥進泥量、稀釋水、主機轉速）進行試驗分析，同時進行離心機恒扭矩試驗，得出恒扭矩設置數值和最佳輔機扭矩目標值，最終確定該型號離心脫水機的運行區間；在該運行區間內進行168 h性能考核試驗，最終得出最佳運行參數和運行結果，對類似大型污泥脫水系統工藝運行具有參考意義。
Abstract:The process design, equipment parameters and sludge feeding parameter correction of centrifugal dewatering system for sludge treatment and disposal phase Ⅱ project of Bailonggang sewage treatment plant are introduced. On the basis of practical commissioning, several key factors such as agent dosage, sludge inflow, dilution water, and main engine speed, which affect the water content of the sludge outflow from the centrifugal dehydrator are tested and analyzed. At the same time, the constant torque test of the centrifuge is carried out, and the setting value of constant torque and the target value of the best auxiliary machine torque are obtained. Finally, the operation range of this type of centrifugal dehydrator is determined. The 168 h performance test is carried out in the operation range, and the optimal operation parameters are obtained, which has reference significance for similar large sludge dewatering system process operation.
相似文獻/References:
[1]馬慧峰,錢志軍,熊仁久,等.生物瀝浸+廂式隔膜板框壓濾機用于城鎮污泥脫水[J].中國給水排水,2018,34(20):112.
MA Hui feng,QIAN Zhi jun,XIONG Ren jiu,et al.Application of Bioleaching and Chamber Diaphragm Plate Filter Press System in Sludge Dewatering Process[J].China Water & Wastewater,2018,34(12):112.
[2]郝曉地,于文波,時琛,等.污泥焚燒灰分磷回收潛力分析及其市場前景[J].中國給水排水,2021,37(4):5.
HAO Xiao-di,YU Wen-bo,SHI Chen,et al.Potential Analysis and Market Prospects of Phosphorus Recovery from the Bottom Ashes of Sludge Incineration[J].China Water & Wastewater,2021,37(12):5.
[3]應基光,林莉峰,邵欽.基于鼓泡流化床的污泥焚燒保護控制[J].中國給水排水,2021,37(10):133.
YING Ji-guang,LIN Li-feng,SHAO Qin.Protection Control of Sludge Incineration Based on Bubbling Fluidized Bed[J].China Water & Wastewater,2021,37(12):133.
[4]楊漢文,王建國,李沖,等.市政污泥干化焚燒技術應用工程案例[J].中國給水排水,2021,37(12):136.
YANG Han-wen,WANG Jian-guo,LI Chong,et al.Application Project of Municipal Sludge Drying and Incineration Technology[J].China Water & Wastewater,2021,37(12):136.
[5]段妮娜,譚學軍,張辰.污水處理廠污泥獨立焚燒的熱力計算方法解析[J].中國給水排水,2021,37(16):83.
DUAN Ni-na,TAN Xue-jun,ZHANG Chen.Analysis of Sewage Sludge Mono-incineration Thermodynamic Calculation Method in a Sewage Treatment Plant[J].China Water & Wastewater,2021,37(12):83.
[6]應基光,林莉峰,王麗花.白龍港污泥二期煙氣在線監測系統設計與調試[J].中國給水排水,2022,38(6):117.
YINGJi-guang,LIN Li-feng,WANG Li-hua.Design and Commissioning of CEMS for Bailonggang Phase Ⅱ Sludge Project[J].China Water & Wastewater,2022,38(12):117.
[7]孟鑫,陳偉,陳柏校.蕭山4 000 t/d污泥集中焚燒處理項目實踐[J].中國給水排水,2022,38(8):127.
MENGXin,CHENWei,CHENBai-xiao.Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project[J].China Water & Wastewater,2022,38(12):127.
[8]朱運濤,林莉峰,趙林輝.污泥流化床焚燒煙氣污染物排放特性研究[J].中國給水排水,2022,38(11):115.
ZHUYun-tao,LINLi-feng,ZHAOLin-hui.Emission Characteristics of Pollutants in Flue Gas from Sludge Fluidized Bed Incineration Process[J].China Water & Wastewater,2022,38(12):115.
[9]汪蕓蕓,李夢瓊,林莉峰.鼓泡流化床污泥焚燒爐焚燒控制技術研究[J].中國給水排水,2022,38(18):42.
WANGYun-yun,LI Meng-qiong,LINLi-feng.Study on Incineration Control Technology of Sludge Bubbling Fluidized Bed Incinerator[J].China Water & Wastewater,2022,38(12):42.
[10]湯連生,周展朋,鄭鄧衡,等.聚乙二醇溶液滲析聯合真空的污泥脫水研究[J].中國給水排水,2023,39(9):78.
TANGLian-sheng,ZHOUZhan-peng,ZHENGDeng-heng,et al.Sludge Dewatering Performance of Polyethylene Glycol Solution Dialysis Combined with Vacuum Pressure[J].China Water & Wastewater,2023,39(12):78.
更新日期/Last Update: 2021-06-17
中國給水排水雜志社官方網所有資料均源于網上的共享資源及期刊共享，請?zhí)貏e注意勿做其他非法用途 如有侵犯您的版權或其他有損您利益的行為，請聯系指出，本網會立即進行改正或刪除有關內容
論文發表投稿郵箱：cnwater@vip.163.com
CopyRight (C)2016 中國給水排水雜志社官方網 版權所有 津ICP備20004590號
首 頁
期刊介紹
編委會
投稿須知
文章查詢
學術會議
廣告合作
發行訂閱
電子版索閱
網上訂閱
在線留言
English
上一篇下一篇
PDF下載
[1]趙林輝,林莉峰,朱運濤.大型污泥焚燒項目的污泥脫水運行優化研究[J].中國給水排水,2021,37(12):145-150.
ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao.Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project[J].China Water & Wastewater,2021,37(12):145-150.點擊復制
大型污泥焚燒項目的污泥脫水運行優化研究
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第37卷 期數: 2021年第12期 頁碼: 145-150 欄目: 出版日期: 2021-06-17
Title:Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project
作者:趙林輝，林莉峰，朱運濤(上海市政工程設計研究總院<集團>有限公司，上海200092)
Author(s):ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao(Shanghai Municipal Engineering Design Institute Co. Ltd., Shanghai 200092, China)
關鍵詞:污泥焚燒; 污泥脫水; 運行優化
Keywords:sludge incineration; sludge dewatering; operation optimization
摘要:介紹了白龍港污水處理廠污泥處理處置二期工程離心脫水系統的工藝設計、設備參數和進泥參數校正情況，并以實際調試為依據，對影響離心脫水機出泥含水率的幾個重要因子（藥劑投加量、污泥進泥量、稀釋水、主機轉速）進行試驗分析，同時進行離心機恒扭矩試驗，得出恒扭矩設置數值和最佳輔機扭矩目標值，最終確定該型號離心脫水機的運行區間；在該運行區間內進行168 h性能考核試驗，最終得出最佳運行參數和運行結果，對類似大型污泥脫水系統工藝運行具有參考意義。
Abstract:The process design, equipment parameters and sludge feeding parameter correction of centrifugal dewatering system for sludge treatment and disposal phase Ⅱ project of Bailonggang sewage treatment plant are introduced. On the basis of practical commissioning, several key factors such as agent dosage, sludge inflow, dilution water, and main engine speed, which affect the water content of the sludge outflow from the centrifugal dehydrator are tested and analyzed. At the same time, the constant torque test of the centrifuge is carried out, and the setting value of constant torque and the target value of the best auxiliary machine torque are obtained. Finally, the operation range of this type of centrifugal dehydrator is determined. The 168 h performance test is carried out in the operation range, and the optimal operation parameters are obtained, which has reference significance for similar large sludge dewatering system process operation.
相似文獻/References:
[1]馬慧峰,錢志軍,熊仁久,等.生物瀝浸+廂式隔膜板框壓濾機用于城鎮污泥脫水[J].中國給水排水,2018,34(20):112.
MA Hui feng,QIAN Zhi jun,XIONG Ren jiu,et al.Application of Bioleaching and Chamber Diaphragm Plate Filter Press System in Sludge Dewatering Process[J].China Water & Wastewater,2018,34(12):112.
[2]郝曉地,于文波,時琛,等.污泥焚燒灰分磷回收潛力分析及其市場前景[J].中國給水排水,2021,37(4):5.
HAO Xiao-di,YU Wen-bo,SHI Chen,et al.Potential Analysis and Market Prospects of Phosphorus Recovery from the Bottom Ashes of Sludge Incineration[J].China Water & Wastewater,2021,37(12):5.
[3]應基光,林莉峰,邵欽.基于鼓泡流化床的污泥焚燒保護控制[J].中國給水排水,2021,37(10):133.
YING Ji-guang,LIN Li-feng,SHAO Qin.Protection Control of Sludge Incineration Based on Bubbling Fluidized Bed[J].China Water & Wastewater,2021,37(12):133.
[4]楊漢文,王建國,李沖,等.市政污泥干化焚燒技術應用工程案例[J].中國給水排水,2021,37(12):136.
YANG Han-wen,WANG Jian-guo,LI Chong,et al.Application Project of Municipal Sludge Drying and Incineration Technology[J].China Water & Wastewater,2021,37(12):136.
[5]段妮娜,譚學軍,張辰.污水處理廠污泥獨立焚燒的熱力計算方法解析[J].中國給水排水,2021,37(16):83.
DUAN Ni-na,TAN Xue-jun,ZHANG Chen.Analysis of Sewage Sludge Mono-incineration Thermodynamic Calculation Method in a Sewage Treatment Plant[J].China Water & Wastewater,2021,37(12):83.
[6]應基光,林莉峰,王麗花.白龍港污泥二期煙氣在線監測系統設計與調試[J].中國給水排水,2022,38(6):117.
YINGJi-guang,LIN Li-feng,WANG Li-hua.Design and Commissioning of CEMS for Bailonggang Phase Ⅱ Sludge Project[J].China Water & Wastewater,2022,38(12):117.
[7]孟鑫,陳偉,陳柏校.蕭山4 000 t/d污泥集中焚燒處理項目實踐[J].中國給水排水,2022,38(8):127.
MENGXin,CHENWei,CHENBai-xiao.Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project[J].China Water & Wastewater,2022,38(12):127.
[8]朱運濤,林莉峰,趙林輝.污泥流化床焚燒煙氣污染物排放特性研究[J].中國給水排水,2022,38(11):115.
ZHUYun-tao,LINLi-feng,ZHAOLin-hui.Emission Characteristics of Pollutants in Flue Gas from Sludge Fluidized Bed Incineration Process[J].China Water & Wastewater,2022,38(12):115.
[9]汪蕓蕓,李夢瓊,林莉峰.鼓泡流化床污泥焚燒爐焚燒控制技術研究[J].中國給水排水,2022,38(18):42.
WANGYun-yun,LI Meng-qiong,LINLi-feng.Study on Incineration Control Technology of Sludge Bubbling Fluidized Bed Incinerator[J].China Water & Wastewater,2022,38(12):42.
[10]湯連生,周展朋,鄭鄧衡,等.聚乙二醇溶液滲析聯合真空的污泥脫水研究[J].中國給水排水,2023,39(9):78.
TANGLian-sheng,ZHOUZhan-peng,ZHENGDeng-heng,et al.Sludge Dewatering Performance of Polyethylene Glycol Solution Dialysis Combined with Vacuum Pressure[J].China Water & Wastewater,2023,39(12):78.
更新日期/Last Update: 2021-06-17
中國給水排水雜志社官方網所有資料均源于網上的共享資源及期刊共享，請?zhí)貏e注意勿做其他非法用途 如有侵犯您的版權或其他有損您利益的行為，請聯系指出，本網會立即進行改正或刪除有關內容
論文發表投稿郵箱：cnwater@vip.163.com
CopyRight (C)2016 中國給水排水雜志社官方網 版權所有 津ICP備20004590號
[1]趙林輝,林莉峰,朱運濤.大型污泥焚燒項目的污泥脫水運行優化研究[J].中國給水排水,2021,37(12):145-150.
ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao.Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project[J].China Water & Wastewater,2021,37(12):145-150.
點擊復制
ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao.Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project[J].China Water & Wastewater,2021,37(12):145-150.
大型污泥焚燒項目的污泥脫水運行優化研究
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第37卷 期數: 2021年第12期 頁碼: 145-150 欄目: 出版日期: 2021-06-17
- Title:
- Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project
- 摘要:
- 介紹了白龍港污水處理廠污泥處理處置二期工程離心脫水系統的工藝設計、設備參數和進泥參數校正情況，并以實際調試為依據，對影響離心脫水機出泥含水率的幾個重要因子（藥劑投加量、污泥進泥量、稀釋水、主機轉速）進行試驗分析，同時進行離心機恒扭矩試驗，得出恒扭矩設置數值和最佳輔機扭矩目標值，最終確定該型號離心脫水機的運行區間；在該運行區間內進行168 h性能考核試驗，最終得出最佳運行參數和運行結果，對類似大型污泥脫水系統工藝運行具有參考意義。
- Abstract:
- The process design, equipment parameters and sludge feeding parameter correction of centrifugal dewatering system for sludge treatment and disposal phase Ⅱ project of Bailonggang sewage treatment plant are introduced. On the basis of practical commissioning, several key factors such as agent dosage, sludge inflow, dilution water, and main engine speed, which affect the water content of the sludge outflow from the centrifugal dehydrator are tested and analyzed. At the same time, the constant torque test of the centrifuge is carried out, and the setting value of constant torque and the target value of the best auxiliary machine torque are obtained. Finally, the operation range of this type of centrifugal dehydrator is determined. The 168 h performance test is carried out in the operation range, and the optimal operation parameters are obtained, which has reference significance for similar large sludge dewatering system process operation.
相似文獻/References:
[1]馬慧峰,錢志軍,熊仁久,等.生物瀝浸+廂式隔膜板框壓濾機用于城鎮污泥脫水[J].中國給水排水,2018,34(20):112.
MA Hui feng,QIAN Zhi jun,XIONG Ren jiu,et al.Application of Bioleaching and Chamber Diaphragm Plate Filter Press System in Sludge Dewatering Process[J].China Water & Wastewater,2018,34(12):112.
[2]郝曉地,于文波,時琛,等.污泥焚燒灰分磷回收潛力分析及其市場前景[J].中國給水排水,2021,37(4):5.
HAO Xiao-di,YU Wen-bo,SHI Chen,et al.Potential Analysis and Market Prospects of Phosphorus Recovery from the Bottom Ashes of Sludge Incineration[J].China Water & Wastewater,2021,37(12):5.
[3]應基光,林莉峰,邵欽.基于鼓泡流化床的污泥焚燒保護控制[J].中國給水排水,2021,37(10):133.
YING Ji-guang,LIN Li-feng,SHAO Qin.Protection Control of Sludge Incineration Based on Bubbling Fluidized Bed[J].China Water & Wastewater,2021,37(12):133.
[4]楊漢文,王建國,李沖,等.市政污泥干化焚燒技術應用工程案例[J].中國給水排水,2021,37(12):136.
YANG Han-wen,WANG Jian-guo,LI Chong,et al.Application Project of Municipal Sludge Drying and Incineration Technology[J].China Water & Wastewater,2021,37(12):136.
[5]段妮娜,譚學軍,張辰.污水處理廠污泥獨立焚燒的熱力計算方法解析[J].中國給水排水,2021,37(16):83.
DUAN Ni-na,TAN Xue-jun,ZHANG Chen.Analysis of Sewage Sludge Mono-incineration Thermodynamic Calculation Method in a Sewage Treatment Plant[J].China Water & Wastewater,2021,37(12):83.
[6]應基光,林莉峰,王麗花.白龍港污泥二期煙氣在線監測系統設計與調試[J].中國給水排水,2022,38(6):117.
YINGJi-guang,LIN Li-feng,WANG Li-hua.Design and Commissioning of CEMS for Bailonggang Phase Ⅱ Sludge Project[J].China Water & Wastewater,2022,38(12):117.
[7]孟鑫,陳偉,陳柏校.蕭山4 000 t/d污泥集中焚燒處理項目實踐[J].中國給水排水,2022,38(8):127.
MENGXin,CHENWei,CHENBai-xiao.Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project[J].China Water & Wastewater,2022,38(12):127.
[8]朱運濤,林莉峰,趙林輝.污泥流化床焚燒煙氣污染物排放特性研究[J].中國給水排水,2022,38(11):115.
ZHUYun-tao,LINLi-feng,ZHAOLin-hui.Emission Characteristics of Pollutants in Flue Gas from Sludge Fluidized Bed Incineration Process[J].China Water & Wastewater,2022,38(12):115.
[9]汪蕓蕓,李夢瓊,林莉峰.鼓泡流化床污泥焚燒爐焚燒控制技術研究[J].中國給水排水,2022,38(18):42.
WANGYun-yun,LI Meng-qiong,LINLi-feng.Study on Incineration Control Technology of Sludge Bubbling Fluidized Bed Incinerator[J].China Water & Wastewater,2022,38(12):42.
[10]湯連生,周展朋,鄭鄧衡,等.聚乙二醇溶液滲析聯合真空的污泥脫水研究[J].中國給水排水,2023,39(9):78.
TANGLian-sheng,ZHOUZhan-peng,ZHENGDeng-heng,et al.Sludge Dewatering Performance of Polyethylene Glycol Solution Dialysis Combined with Vacuum Pressure[J].China Water & Wastewater,2023,39(12):78.
更新日期/Last Update: 2021-06-17
Alt + K
